Product ID:MIL-P-23377E TYPE 1 CLASS 1 (COMP A & B)
MSDS Date:11/01/1988
FSC:8010
NIIN:00-082-2450
Kit Part:Y
MSDS Number: BHFMG

KOPPERS CO INC

3000 KOPPERS BLDG
PITTSBURGH, PA 15219-1818
US

Emergency Phone: 800-553-5631/800-424-9300

Info Phone: 412-227-2911

Cage: 80592

KOPPERS CO INC

PITTSBURGH, PA 15219-1818 US

Cage: 80592

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: <3%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

TALC (CONTAINING NO ASBESTOS)

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: <5%

OSHA PEL 2 MG/M3 RDUST

ACGIH TLV: 2 MG/M3 RDUST; 9192

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: <10%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: <15%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: <40%

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

AMORPHOUS SILICON DIOXIDE

CAS: 112945-52-5

RTECS: VV7310000

Fraction By Weight: <3%

OSHA PEL 20MPPCF MG/M3

STRONTIUM CHROMATE (SARA III)

CAS: 7789-06-2

RTECS: GB3240000

Fraction By Weight: <15%

OSHA PEL 0.1 PPM CRO3;CEILING

ACGIH TLV: 0.0005MG CR/M3;A2;93

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:CHRONIC EXPOSURE TO CERTAIN CHROMIUM
COMPOUNDS HAS BEEN SHOWN TO RESULT IN AN INCREASED INCIDENCE OF
LUNG CANCER.
Explanation of Carcinogenicity:IARC:RESP CARCINOGNCTY IN MEN EXPOSD
DURG CHROMATE PRODUCTN.NTP:INCREASED LUNG CANCER IN
WORKERS/CHROMATE PROD INDUSTRY.
Effects of Overexposure:EYES:MAY CAUSE IRRITATN,TEARG,CORNEAL INJURY.
SKIN:MAY CAUSE IRRITATN,DERMATI- TIS,SYSTEMIC EFFECTS FROM
ABSORPTION.IRRITATION & POSSIBLE SENSITIZATION FROM DUSTS.
INHALATION:MAY CAUSE RESPIRATORY TRACT IRRITATN & CNS
EFFECTS,SEVEREMUCOUS MEMBRANE IRRITATN. INGESTN: MAY CAUSE
GASTROINTESTINAL DISTURBANCES.
Medical Cond Aggravated by Exposure:AILMENTS INVOLVG SKIN, EYE,
RESPIRATORY TRACT, KIDNEY, LIVER, BONE MARROW, BLOOD CELLS,
CENTRAL NERVOUS SYSTEM ARE AT GREATER THAN NORMAL RISK OF
DEVELOPING SIDE EFFECTS WHEN EXPOSED TO THIS MATL.

First Aid:EYES: IMMEDIATELY FLUSH W/LARGE AMOUNTS OF WATER FOR 15
MINUTES. SEEK MED AID.SKIN: WASH THOROUGHLY W/SOAP AND WATER. IF
IRRITATION PERSISTS, SEEK MED AID. INHALATION: REMOVE FROM
EXPOSURE. FOR STOPPED OR DIFFICULT BREATHING, ADMINI-STER
ARTIFICIAL RESPIRATION/OXYGEN AS INDICATED. SEEK MED AID.
INGESTION: DO NOT INDUCE VOMITING. SEEK MED AID.

Flash Point:**
Extinguishing Media:WATER MAY BE INEFFECTIVE. USE DRY CHEMICAL, CARBON
DIOXIDE,FOAM OR WATER SPRAY.
Fire Fighting Procedures:WEAR COMPLETE FIRE SERVICE PROTECTV EQUIPMENT,
INCLUDG S.C.B.A. USE WTR TO COOLFIRE-EXPOSED
CONTNR/STRUCTURE/PROTECT PERSONNEL. FIRE MAY GIVE OFF TOXIC VAPORS
Unusual Fire/Explosion Hazard:VAPORS HEAVIER THAN AIR,MAY TRAVEL ON
GROUND,PIT,OR SEWER LINE TO DISTANT SOURCEOF IGN & FLASH BACK.CLOSD
CONTNRS MAY EXPLODE WHEN EXPOSD TO EXTREME HEAT(FIRE).

Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. STAY UPWIND.
SMALLSPILLS: TAKE UP W/SAND OR OTHER NONCOMBUSTIBLE ABSORBENT
MATL. FLUSH AREA W/WTR. LARGE SPILLS: DIKE FOR LATER DISPOSAL,
CONTAIN RUNOFF FROM FIRE CONTROL AND DILUTION WATER.

Handling and Storage Precautions:DON'T ENTER/USE IN CONFIND
SPACE/TANK/PIT W/OUT PROPR VENTILATN.USE CONFIND ENTRY
PROCEDURES.KEEP IN CLOSD,LABELD CONTNR W/IN COOL,DRY-VENTLTD AREA.
Other Precautions:DON'T STORE/USE IN/AROUND HOME.GROUND & BOND
DRUMS.DON'T USE PRESSURE TO EMPTY DRUMS.DON'T USE BEFORE
READING/UNDERSTANDG MANUFACTURERS PRECAUTIONS.WASH EXPOS-ED AREAS
THOROUGHLY AFTER CONTACT & BEFO RE EATG,DRINKG,USING WASHRM/TOBACCO
PROD

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW TLV(PEL),USE NIOSH/ MSHA APPROVED UNITS. IF WITHIN
OSHA PROTECTION FACTOR, AIR PURIFYING OV/FILTER UNITS OK.
Ventilation:GENERAL/LOCAL EXHAUST
LOCAL EXHAUST NECESSARY FOR USE IN ENCLOSED/CONFINED SPACES
Protective Gloves:INDUSTRL RESISTANT,FLEXIBLE-TYPE GLOVES
Eye Protection:SAFETY GLASSES,GOGGLES,SIDE/FACE SHIELDS
Other Protective Equipment:INDUSTRIAL-TYPE WORK CLOTHING (HEAD/NECK
COVER, APRONS, JACKETS, PANTS, COVERALLS, BOOTS/OTHER SAFETY
FOOTWEAR).
Supplemental Safety and Health
NOTE TO PHYS:THERE'S NO ANTIDOTE FOR OVEREXPOSURE EFFECTS OF THIS
MATL.TREATMENTSHOULD BE DIRECTED AT CONTRL OF SYMPTOMS & THE
CLINICAL CONDITN.//DON'T BREATHE VAPORS OR MISTS.DON'T GET ON
SKIN,EYES,C LOTHING. STORAGE:PROTECT FROM PHYS DAM-AGE.KEEP
CONTNRS CLOSED WHEN MATL ISN'T IN USE.MAINTAIN GOOD HOUSEKEEPING.

HCC:F2
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Density:>1
Spec Gravity:8.6-9.4 LBS/GAL
Evaporation Rate & Reference:>1
Solubility in Water:MODERATELY
Appearance and Odor:YELLOW-COLORED LIQUID WITH A STRONG SOLVENT ODOR.
Percent Volatiles by Volume:71

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, HYDROFLUORIC ACID, ALKALI, STRONG ACIDS, REDUCING
AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN

Waste Disposal Methods:THIS IS A US EPA DEFINED IGNITABLE HAZARDS
WASTE. DISPOSE OF AS AN IGNITABLE WASTE IN ACCORDANCE W/ LOCAL,
STATE & FEDERAL REGULATIONS. PLACE IN TIGHTLY SEALED, LABELED
CONTAINERS. IF OVER 100 POUNDS, REPORT TO NATIONAL RESPONSE
CENTER.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.